Category: News

   Air compressors can be divided into low-pressure air compressors and high-pressure air compressors according to the level of pressure. Exhaust pressure refers to the highest pressure of the air compressor exhaust gas, generally expressed in bar or Mpa, 1bar=0.1 Mpa users often refer to the pressure unit as:…

Leakage: When the screw air compressor is running, there is a gap between the rotors and between the rotor and the casing, and no direct contact will cause gas leakage. When the gas pressure rises through the suction pipe gap and suction groove, it can reduce the air discharge. Therefore,…

The all-in-one cold dryer does not start ① Check whether the air dryer is correctly connected to the power supply. ②Check if the neutral line is missing. ③ Check whether the switch is malfunctioning. ④ Check whether the high and low voltage protectors have tripped for protection. ⑤ Check whether…

 The air compressor can only be started when the indoor temperature of the air compressor room is kept above 5°C.   Close the sliding door of the exhaust air outlet of the air compressor unit that is not open, and close the indoor hot air exhaust outlet to ensure…

Effects of air compressor vibration:   Cause failures such as cylinder pulling and tile burning.   Increase equipment power consumption and waste energy.   Make noise and affect the surrounding environment and workers.   Cause instrument failure and affect the stability of normal operation.   The wear of the frictional…

  Low noise: The output air pressure is stable without fluctuation, minimizing noise pollution. It is suitable for analysis and testing, laboratory support, laboratories of various universities, research institutes, environmental protection, health and epidemic prevention and other testing departments.   Oil-free and water-free: The oil-free air compressor solves the problem…

There are several ways to reduce motor losses:   Stator loss. Increase the full slot rate of the stator slot, which is better for low-voltage small motors. The full slot rate of the stator can be increased by applying winding and insulation dimensions, and a large cross-sectional area of the…

Good ventilation conditions: This is beneficial to ensure that the ambient temperature is within a suitable range, so as to ensure that the exhaust temperature will not be too high.   Good air quality: In theory, the air quality is directly related to the service life of the oil-free screw…

After the machine is cleaned and installed, the operating parameters of the air compressor should be adjusted to ensure the normal and safe operation of the social insurance:   Preparations before starting the screw air compressor: (1) Belt (coupling) correction: If the air compressor is driven by a belt, the…

The following points may cause part of the flue gas of the screw air compressor:   Oil separator failure: replace the oil separator.   Low exhaust pressure: increase the exhaust pressure (adjust the setting value of the pressure switch).   The oil level is too high: check the oil level…